MAINTENANCE SCHEDULES - GASOLINE ENGINES - EXPORT

There are two maintenance schedules that show the required service for your vehicle.

First is Schedule “A”. It is for vehicles that are not operated under any of the conditions listed under Schedule “B.”

Second is Schedule "B". It is for vehicles that are operated under the conditions that are listed below and at the beginning of the schedule.

  • Day or night temperatures are below 0°C (32°F).
  • Stop and go driving.
  • Extensive engine idling.
  • Driving in dusty conditions.
  • Short trips of less than 16.2 km (10 miles).
  • More than 50% of your driving is at sustained high speeds during hot weather, above 32°C (90°F).
  • Trailer towing.
  • Taxi, police, or delivery service (commercial service).
  • Off-road or desert driving.

Use the schedule that best describes your driving conditions. Where time and mileage are listed, follow the interval that occurs first.

CAUTION: Failure to perform the required maintenance items may result in damage to the vehicle.

    At Each Stop for Fuel

  • Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
  • Check the windshield washer solvent, add as required.

    Once a Month

  • Check the tire pressure and look for unusual wear or damage.
  • Inspect the battery, and clean and tighten the terminals as required.
  • Check the fluid levels of the coolant reservoir, brake master cylinder, and transmission, and add as needed.
  • Check all lights and all other electrical items for correct operation.

    At Each Oil Change

  • Change the engine oil filter.
  • Inspect the exhaust system.
  • Inspect brake hoses.
  • Check the coolant level, hoses, and clamps.
  • Inspect manual transmission fluid level — if equipped.
  • After completion of off-road operation, the underside of the vehicle should be thoroughly inspected. Examine threaded fasteners for looseness.

Schedule “A”


Kilometers
  		12 000
  		24 000
  		36 000
  		48 000
  		60 000
  
(Miles)
  		(7,500)
  		(15,000)
  		(22,500)
  		(30,000)
  		(37,500)
  
[Months]
  		[6]
  		[12]
  		[18]
  		[24]
  		[30]
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		X
  		X
  		X
  		X
  
Inspect the engine air filter element, replace if necessary.
  		      X
  		  
Replace the spark plugs.
  		      X
  		  
Inspect the brake linings.
  		    X
  		    
Inspect the transfer case fluid.
  		      X
  		  


Kilometers
  		72 000
  		84 000
  		96 000
  		108 000
 
(Miles)
  		(45,000)
  		(52,500)
  		(60,000)
  		(67,500)
  
[Months]
  		[36]
  		 [42]
  		[48]
  		 [54]
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		X
  		X
  		X
  
Inspect the engine air filter element, replace if necessary.
  		    X
  		  
Inspect and replace the PCV valve, if necessary♦.
  		    X
  		  
Replace the spark plugs.
  		    X
  		  
Inspect the brake linings.
  		X
  		    X
  
Inspect and replace the Auto Tension Drive Belt, as needed.
  		    X
  		  
Inspect the transfer case fluid.
  		    X
  		  


Kilometers
  		120 000
  		132 000
  		144 000
  		156 000
 
(Miles)
  		(75,000)
  		(82,500)
  		(90,000)
  		(97,500)
  
[Months]
  		[60]
  		[66]
  		[72]
  		[78]
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		X
  		X
  		X
  
Inspect the engine air filter element, replace if necessary.
  		    X
  		  
Replace the spark plugs.
  		    X
  		  
Inspect and replace the PCV valve, if necessary.♦
 		    X
  		  
Inspect the brake linings.
  		    X
  		  
Inspect the drive belt and replace as needed. Not required if previously replaced.
  		X
  		  X
  		  
Flush and replace the engine coolant at 60 months, regardless of mileage.
  		X
  		      
Inspect the transfer case fluid.
  		    X
  		  


Kilometers
  		160 000
  		168 000
  		180 000
  		192 000
  
(Miles)
  		(100,000)
  		(105,000)
  		(112,500)
  		(120,000)
  
[Months]
  		  [84]
  		[90]
  		[96]
  
Change the engine oil and engine oil filter.
 		  X
  		X
  		X
  
Rotate the tires.
  		  X
  		X
  		X
  
Inspect the engine air filter element, replace if necessary.
  		      X
  
Replace the spark plugs.
  		      X
  
Inspect and replace the PCV valve, if necessary.♦
 		      X
  
Inspect the brake linings.
  		    X
  		  
Inspect the drive belt and replace as needed. Not required if previously replaced.
  		  X
  		  X
  
Flush and replace the engine coolant if not done at 60 months.
  		X
  		      
Drain the transfer case, and refill.
  		      X
  

♦ This maintenance is recommended by the manufacturer to the owner, but it is not required to maintain emissions warranty.


Schedule “B”

Follow schedule “B” if you usually operate your vehicle under one or more of the following conditions.

  • Day or night temperatures are below 0°C (32°F).
  • Stop and go driving.
  • Extensive engine idling.
  • Driving in dusty conditions.
  • Short trips of less than 16.2 km (10 miles).
  • More than 50% of your driving is at sustained high speeds during hot weather, above 32°C (90°F).
  • Trailer towing.
  • Taxi, police, or delivery service (commercial service).
  • Off-road or desert driving.

Kilometers
  		5 000
  		10 000
  		14 000
  		19 000
  		24 000
  
(Miles)
  		(3,000)
  		(6,000)
  		(9,000)
  		(12,000)
  		(15,000)
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		  X
  		  X
  		  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Inspect the brake linings.
  		      X
  		  
Drain and refill the front and rear axle fluid‡
  		        X
  


Kilometers
  		29 000
  		34 000
  		38 000
  		43 000
  		48 000
  
(Miles)
  		(18,000)
 		(21,000)
  		(24,000)
 		(27,000)
  		(30,000)
 
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		  X
  		  X
  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Replace the spark plugs.
  		        X
  
Inspect and replace the PCV valve, if necessary.♦
  		        X
  
Inspect the brake linings.
  		    X
  		    
Drain and refill the front and rear axle fluid‡
  		        X
  
Inspect the transfer case fluid, add if necessary.
  		        X
  


Kilometers
  		53 000
  		58 000
  		62 000
  		67 000
  		72 000
  
(Miles)
  		(33,000)
  		(36,000)
  		(39,000)
  		(42,000)
  		(45,000)
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		  X
  		  X
  		  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Inspect the brake linings.
  		  X
  		      
Drain and refill the front and rear axle fluid‡
  		        X
  
Inspect the drive belt and replace as needed.
  		        X
  


Kilometers
  		77 000
  		82 000
  		86 000
  		91 000
  		96 000
  
(Miles)
  		(48,000)
  		(51,000)
  		(54,000)
  		(57,000)
  		(60,000)
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		  X
  		  X
  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Replace the spark plugs.
  		        X
  
Inspect and replace the PCV valve, if necessary.♦
  		        X
  
Inspect the brake linings.
  		X
  		      X
  
Drain and refill the front and rear axle fluid‡
  		        X
  
Drain and refill the automatic transmission fluid, and replace main sump filter.
  		        X
  
Inspect the drive belt and replace as needed. Not required if belt was previously replaced.
  		        X
  
Drain and refill the transfer case fluid.
  		        X
  
Flush and replace the engine coolant/anti-freeze at 60 months, if not done at 102,000 miles (163 000 km).
  		        X
  


Kilometers
  		101 000
  		106 000
  		110 000
  		115 000
  		120 000
  
(Miles)
  		(63,000)
  		(66,000)
  		(69,000)
  		(72,000)
  		(75,000)
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		  X
  		  X
  		  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Inspect the brake linings.
  		      X
  		  
Drain and refill the front and rear axle fluid‡
  		        X
  
Inspect the drive belt and replace as needed. Not required if belt was previously replaced.
  		        X
  


Kilometers
  		125 000
  		130 000
  		134 000
  		139 000
  		144 000
  
(Miles)
  		(78,000)
  		(81,000)
  		(84,000)
  		(87,000)
  		(90,000)
  
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		  X
  		  X
  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Replace the spark plugs.
  		        X
  
Inspect and replace the PCV valve, if necessary.♦
  		        X
  
Inspect the brake linings.
  		    X
  		    
Drain and refill the front and rear axle fluid‡
  		        X
  
Inspect the drive belt and replace as needed. Not required if belt was previously replaced.
  		        X
  
Inspect the transfer case fluid, add if necessary.
  		        X
  


Kilometers
  		149 000
  		154 000
  		158 000
  		163 000
  		168 000
  
(Miles)
  		(93,000)
  		(96,000)
  		(99,000)
  		(102,000)
  		(105,000)
 
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		  X
  		  X
  		  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Inspect the brake linings.
  		  X
  		      
Drain and refill the front and rear axle fluid‡
  		        X
  
Inspect the drive belt and replace as needed. Not required if belt was previously replaced.
  		        X
  
Flush and replace the engine coolant/anti-freeze, if not done at 60 months.
  		      X
  		  


Kilometers
  		173 000
  		 178 000
  		182 000
  		187 000
 		192 000
  
(Miles)
  		(108,000)
 		(111,000)
  		(114,000)
 		(117,000)
  		(120,000)
 
Change the engine oil and engine oil filter.
 		X
  		X
  		X
  		X
  		X
  
Rotate the tires.
  		X
  		  X
  		  X
  
Inspect the engine air filter element, replace if necessary.
  		        X
  
Replace the spark plugs.
  		        X
  
Inspect and replace the PCV valve, if necessary.♦
  		        X
  
Inspect the brake linings.
  		X
  		      X
  
Drain and refill the front and rear axle fluid‡
  		        X
  
Drain and refill the automatic transmission fluid, and replace main sump filter.
  		        X
  
Inspect the drive belt and replace as needed. Not required if belt was previously replaced.
  		        X
  
Drain and refill the transfer case fluid.
  		        X
  

♦ This maintenance is recommended by the manufacturer to the owner, but it is not required to maintain emissions warranty.

‡Off-highway operation, trailer towing, taxi, limousine, bus, snow plowing, or other types of commercial service or prolonged operation with heavy loading, especially in hot weather, require front and rear axle service indicated with a ‡ in Schedule “B”. Perform these services if the vehicle is usually operated under these conditions.